Last July, we wrote about a new carbon foam AGM lead acid battery technology that was taking the industry by storm. The Firefly Oasis carbon foam AGM battery was developed by Caterpillar to replace the lead acid batteries that they were using in their work vehicles. They found that the old battery technology could not, consistently, withstand constant vibration, inconsistent charging or long periods without charging. This new technology is based on the sealed valve-regulated design of a conventional lead acid battery but the negative plate has been replaced by a light-weight, sulfation-resistant, microcell material.
The number one reason that batteries fail is because they are not regularly charged to completion. The microcell material gives the battery a higher density, allowing it to accept and disperse power faster. The Firefly can deliver 80% of usable battery capacity (depth of discharge or DOD to 20%) and still offer three to four times the battery life of a standard AGM. One of the biggest benefits of this technology is that the battery can be left in a partial state of discharge (i.e. extended cruising, sitting on a trailer or in storage without power) and it will not lose any permanent capacity. You simply have to charge the battery and it will return to 100% of its original capacity.
Owners are now taking more and more land-based comforts with them. This means they are looking for more power, in less space, with less weight. In many cases, there is not enough room to simply add more batteries so owners are looking for a higher usable battery capacity with a much faster ability to charge. In this article, we are going to talk with four boat owners who recently made the switch to Firefly AGM batteries
The first installation we are going to look at is on a Hunter 33.5, that had 4 flooded golf cart batteries for a total capacity of 420Ah or 145Ah of usable battery capacity (i.e. flooded lead acid bulk charging: 50% to 85% DOD while cruising or 35% of usable capacity). The owner, Tim Grady, had done a great deal of research on both lithium and carbon foam technology and chose the Firefly because of the low maintenance and the good reviews that the technology had received. “At the end of the day”, states Tim, “I would rather spend the money now than later and know that I have a far more forgiving battery.” He installed 3 Firefly batteries for a total of 330 Ah or 215 Ah of usable battery capacity (Firefly bulk charging: 20% DOD to 85% DOD or 65% of usable capacity).
The second owner has a Bavaria 46 with limited space for batteries, his original bank had a total battery capacity of 500Ah or 175Ah of usable battery capacity. Because of the limitations of the dimensions, the original lead acid batteries were not installed in battery boxes. This is dangerous with lead acid batteries as the sulphuric acid, that can seep out when the batteries get warm during bulk charging, is highly corrosive. On top of that, owner lives in Alberta and cannot get to the boat on a regular basis to maintain the flooded batteries. This also means that if the shore power is disconnected for a long period of time the lead acid batteries may completely discharge or the water level will drop, exposing the battery plates and potentially causing sulfation. This greatly reduces the life span of a lead acid battery and, in most cases, they do not recover. For this boater, Firefly batteries made perfect sense because they do not require battery boxes and they can be left for extended periods without a charge and will only lose 1 – 2% of their capacity per month. As long as they don’t drop below 20% of capacity, they can be recharged to 100% with no permanent damage. He installed 5 Firefly batteries for a total capacity of 550Ah or 360Ah of usable capacity, nearly doubling the usable battery capacity with no increase in weight or space.
Our third boater purchased a relatively new 20 meter boat, from Florida, that was specifically designed to go from dock to dock. The owner preferred to anchor and was constantly managing the power consumption or running the generator. The boat came with 6 – 8D flooded lead acid batteries that were wired in 24V which gave him 780Ah of total capacity or 273 Ah of usable capacity. Because he had a 24V system, we installed 14 Firefly batteries for a total capacity of 770Ah or 500Ah of usable battery capacity. This gave him an 85% increase in capacity.
The final installation was on an older Monk McQueen that had 6 – 2V batteries that produced 1,100Ah or 385Ah of usable battery capacity. The big challenge was that these 2V batteries weigh almost 55 kilograms each, were in boxes of two, and were incredibly difficult to manoeuvre in and out of the boat. The owner recognized this challenge and made a point of saying he would do it differently the next time. He replaced the current battery bank with 10 Firefly batteries which would give him 1,100Ah but a whopping 715Ah of usable battery capacity.
There are a few things to remember if you are going to change the battery chemistry on your boat, especially if you are switching from flooded lead acid to AGM. The profiles must be changed on your battery charger, external regulator, battery monitor and solar controllers. Some of the newer chargers offer a programmable mode that allows you to enter specific voltages. You will want to charge the Firefly to 14.4 for the bulk phase and 13.2 for the float phase. You do not need to fully charge the Firefly each cycle, in order to maintain the capacity and only need to perform a complete charge cycle when you want to maximize the capacity for the following discharge cycle. The Firefly does not require a float charge, but if float charging (due to the longer projected lifespan) it is important to keep the float voltage at or below 13.2V to ensure the battery lasts for as many cycles as possible. For programmable charging sources, adjust the “reset to bulk phase” to occur if the battery voltage drops below 12.0V for more than one minute.
In terms of cost, lead acid batteries will always have the lowest upfront price tag but you have to factor in the maintenance of consistently checking the fluid levels, the inability to always discharge below 50% DOD, the need for a battery box, and the low amount of cycles. Even if you are super conscientious, a lead acid battery will only give you 300 cycles at 50% DOD, a regular AGM will give you 450 cycles at 50% DOD, whereas a carbon foam battery will provide 3,600 cycles at 50% DOD.